INVESTIGATION OF BORON INFLUENCE ON THE STRUCTURE AND PROPERTIES OF MULTICOMPONENT NANOSTRUCTURED TiCaPCON COATINGS
https://doi.org/10.17073/1997-308X-2016-4-94-103
Abstract
Multicomponent nanostructured TiCaPCON–B coatings with 7,4–15,0 at.% of boron were obtained by magnetron sputtering. It was shown that all elements were uniformly distributed over the coating thickness. The TiCaPCON–B coatings revealed a dense columnar structure with a column width less than 80 nm. It was found that the introduction of boron changed the phase composition of the coatings, but had no significant effect on their morphology. The base of the TiCaPCON–B coatings consisted of free carbon and Ti(C, N), TiB2, BN phases. The study of mechanical properties revealed that the coatings had a relatively high hardness (20–24 GPa) and low Young’s modulus (213–231 GPa). The coatings exhibited hydrophilic properties within the 24-hour exposure to air. Depending on the boron content in the coating, its rate of release into normal saline was 17–24 mkg/(l·сm2·day). In vitro biological studies showed 30–40 % improvement in bioactivity of coatings containing 12,7–15,0 at.% of boron as compared with titanium.
About the Authors
I. V. Sukhorukova
«MISIS»
Russian Federation
engineer of Scientific-research laboratory «Inorganic Nanomaterials», National University of Science and Technology (NUST) «MISIS»
Russian Federation
engineer of Scientific-research laboratory «Inorganic Nanomaterials», National University of Science and Technology (NUST) «MISIS»
I. Yu. Zhitnyak
Russian Oncological Scientific Centre (ROSC) n.a. N.A. Blokhin
Russian Federation
Cand. Sci. (Biol.), research scientist of Laboratory of carcinogenesis mechanisms
Russian Federation
Cand. Sci. (Biol.), research scientist of Laboratory of carcinogenesis mechanisms
N. A. Gloushankova
Russian Oncological Scientific Centre (ROSC) n.a. N.A. Blokhin
Russian Federation
Dr. Sci. (Biol.), head of Laboratory of carcinogenesis mechanisms
Russian Federation
Dr. Sci. (Biol.), head of Laboratory of carcinogenesis mechanisms
D. V. Shtansky
«MISIS»
Russian Federation
Dr. Sci. (Phys.-Math.), professor of the Department of powder metallurgy and multifunctional coatings NUST «MISIS», chief research scientist of Scientific-educational Centre SHS MISIS–ISMAN, head of Scientific-research laboratory «Inorganic Nanomaterials» NUST «MISIS»
Russian Federation
Dr. Sci. (Phys.-Math.), professor of the Department of powder metallurgy and multifunctional coatings NUST «MISIS», chief research scientist of Scientific-educational Centre SHS MISIS–ISMAN, head of Scientific-research laboratory «Inorganic Nanomaterials» NUST «MISIS»
References
1. Forrest H. Nielsen. Update on human health effects of boron. J. Trace. Elem. Med. Bio. 2014. Vol. 28. P. 383—387.
2. Jacobs R.T., Plattner J.J., Keenan M. Boron-based drugs as antiprotozoals. Curr. Opin. Infect. Dis. 2011. Vol. 24. P. 586—592.
3. Baker S.J., Ding C.Z., Akama T., Zhang Y.K., Hernandez V., Xia Y. Therapeutic potential of boron-containing compounds. Future Med. Chem. 2009. Vol. 1. No. 7. P. 1275— 1288.
4. Chen X., Schauder S., Potier N., Van Dorsselaer A., Pelczer I. Structural identification of a bacterial quorum-sensing signal containing boro. Nature. 2002. Vol. 415. P. 545—549.
5. Lowery C.A., Salzameda N.T., Sawada D., Kaufmann G.F., Janda K.D. Medicinal chemistry as a conduit for the modulation of quorum sensing. J. Med. Chem. 2010. Vol. 53. P. 7467—7489.
6. Reid R.J., Hayes J.E., Post A., Stangoulis J.C.R., Graham R.D. A critical analysis of boron toxicity in plants. Plant. Cell Environ. 2004. Vol. 25. P. 1405—1414.
7. Camgöz B., Saç M.M., Bolca M., Özen F., Oruç Ö.G., Demi-rel N. Investigation of radioactive and chemical contents of thermal waters; Izmir Seferihisar region representative. Ekoloji. 2010. Vol. 19. No. 76. P. 78—87.
8. Yang H., Wang Y., Xue X. Influences of glycerol as an efficient doping agent on crystal structureand antibacterial activity of B—TiO2 nano-materials. Colloid. Surf. B. 2014. Vol. 122. P. 701—708.
9. Bursali E.A., Coskun S., Kizil M., Yurdakoc M. Synthesis, characterization and in vitro antimicrobial activities of boron/starch/polyvinyl alcohol hydrogels. Carbohyd. Polym. 2011. Vol. 83. P. 1377—1383.
10. Wang Y., Xue X., Yang H. Synthesis and antimicrobial activity of boron-doped titania nano-materials. Chinese J. Chem. Eng. 2014. Vol. 22(4). P. 474—479.
11. Xue X., Wang Y., Yang H. Preparation and characterization of boron-doped titania nano-materials with antibacterial activity. Appl. Surf. Sci. 2013. Vol. 264. P. 94—99.
12. Wang Y., Xue X., Yang H. Preparation and characterization of carbon or/and boron-doped titania nano-materials with antibacterial activity. Ceram. Int. 2014. Vol. 40. P. 12533—12537.
13. Huang Q., Yan X., Zhang R., Liu X., Shen Z., Feng Q. Enhanced hydrophilicity and in vitro bioactivity of porous TiO2 film through the incorporation of boron. Ceram. Int. 2015. Vol. 41. No. 3. P. 4452—4459.
14. Ferrari A.C., Robertson J. Interpretation of Raman spectra of disordered and amorphous carbon. Phys. Rev. 2000. Vol. 61. P. 14095—14107.
15. Pierson J.F., Alnot M., Fagot-Revurat Y., Jolly J. Influence of the oxygen flow rate on the properties of reactively sputtered Ti—B—O films. Surf. Coat. Technol. 2003. Vol. 174 — 175. P. 1145—1150.
16. Jeong J., Jung D., Shin E.W., Oh E.-S. Boron-doped TiO2 anode materials for high-rate lithium ion batteries. J. Alloy Compd. 2014. Vol. 604. P. 226—232.
17. Uma T., Izuhara S., Nogami M. Structural and proton conductivity study of P<sub>2</sub>O<sub>5</sub>—TiO<sub>2</sub>—SiO<sub>2</sub> glasses. J. Eur. Ce-ram. Soc. 2006. Vol. 26. P. 2365—2372.
18. Sobczak-Kupiec A., Wzorek Z. The influence of calcination parameters on free calcium oxide content in natural hydroxyapatite. Ceram. Int. 2012. Vol. 38. P. 641—647.
19. Ebrahimi-Kahrizsangi R., Torabi O. Combination of mechanochemical activation and self-propagating behavior for the synthesis of nanocomposite Al<sub>2</sub>O<sub>3</sub>/B<sub>4</sub>C powder. J. Alloy. Compd. 2012. Vol. 514. P. 54—59.
20. Skrinskii P.L., Kuzmichev A.I., Ivashchenko V.I., Ivashchenko L.A., Timofeeva I.I., Butenko O.O., Khizhun O.Yu., Tomi-la T.V., Dub S.N. Structural and mechanical properties of TiN/BCN coatings. Powder Metall. Metal C. 2013. Vol. 52. No. 1—2. P. 73—82.
21. Atalay S., Adiguzel H.I., Atalay F. Infrared absorption study of Fe<sub>2</sub>O<sub>3</sub>—CaO—SiO<sub>2</sub> glass ceramic. Mater. Sci. Eng. A. 2001. Vol. 304-306. P. 796—799.
22. Romanos J., Beckner M., Stalla D., Tekeei A., Suppes G., Jalisatgi S., Lee M., Hawthorne F., Robertson J.D., Firlej L., Kuchta B., Wexler C., Yu P., Pfeifer P. Infrared study of boron—carbon chemical bonds in boron-doped activated carbon. Carbon. 2013. Vol. 54. P. 208—214.
23. Shtansky D.V., Gloushankova N.A., Sheveiko A.N., Kiryukhantsev-Korneev Ph.V., Bashkova I.A., Mavrin B.N., Ignatov S.G., Filipopovich S.Yu., Rojas C. Si-doped multifunctional bioactive nanostructured films. Surf. Coat. Technol. 2010. Vol. 205. P. 728—739.
24. Shtansky D.V., Batenina I.V., Kiryukhantsev-Korneev F.V., Sheveyko A.N., Kuptsov K.A., Anisimova N.Y., Zhitnyak I.Yu., Gloushankova N.A. Ag- and Cu-doped multifunctional bioactive nanostructured TiCaPCON films. Appl. Surf. Sci. 2013. Vol. 285Р. P. 331—343.
25. Sukhorukova I.V., Sheveyko A.N., Zhitnyak I.Y., Gloushankova N.A., Denisenko E.A., Filipovich S.Yu., Ignatov S.G., Shtansky D.V. Towards bioactive yet antibacterial surfaces. Colloid Surf. B. 2015. Vol. 135. P. 158—165.
26. Shtansky D.V., Gloushankova N.A., Bashkova I.A., Kharitonova M.A., Moizhess T.G., Sheveiko A.N., Kiryukhantsev-Korneev Ph.V., Osaka A., Mavrin B.N., Levashov E.A. Ta-doped multifunctional bioactive nanostructured films. Surf. Coat. Technol. 2008. Vol. 202. P. 3615—3624.
27. Vyas A., Lu Y.H., Shen Y.G. Mechanical and tribological properties of multicomponent Ti—B—C—N thin films with varied C contents. Surf. Coat. Technol. 2010. Vol. 204. P. 1528—1534.
28. Lin J., Moore J.J., Mishra B., Pinkas M., Sproul W.D. The structure and mechanical and tribological properties of TiBCN nanocomposite coatings. Acta Mater. 2010. Vol. 58. No. 5. P. 1554—1564.
29. Wang B., Guo X., Bai P. Removal technology of boron dissolved in aqueous solutions: A review. Colloid. Surf. A. 2014. Vol. 444. P. 338—344.
30. Saglam M., Arslan U., Bozkurt S.B., Hakki S.S. Boric acid irrigation as an adjunct to mechanical periodontal therapy in chronic periodontitis patients: a randomized clinical trial. J. Periodontol. 2013. Vol. 84. No. 9. P. 1297—1308.
31. Haesebrouck F., Baele M., De Keyser H., Hermansand K., Pasmans F. Antimicrobial activity of an acetic and boric acid solution against Staphylococcus pseudintermedius. Vlaams Diergen. Tijds. 2009. Vol. 78. No. 2. P. 89—90.
32. Demirer S., Kara M.I., Erciyas K., Ozdemir H., Ozer H., Ay S. Effects of boric acid on experimental periodontitis and alveolar bone loss in rats. Arch. Oral. Biol. 2012. Vol. 57. P. 60—65.
33. Wu C., Miron R., Sculean A., Kaskel S., Doert T., Schulze R., Zhang Y. Proliferation, differentiation and gene expression of osteoblasts in boron-containing associated with dexamethasone deliver from mesoporous bioactive glass scaffolds. Biomaterials. 2011. Vol. 32. P. 7068—7078.
34. Durand L.A.H., Góngora A., López J.M.P., Boccaccini A.R., Zago M.P., Baldi A., Gorustovich A. In vitro endothelial cell response to ionic dissolution products from boron-doped bioactive glass in the SiO<sub>2</sub>—CaO—P<sub>2</sub>O<sub>5</sub>—Na<sub>2</sub>O system. J. Mater. Chem. B. 2014. Vol. 2. P. 7620—7630.
Review
For citations:
Sukhorukova I.V., Zhitnyak I.Yu., Gloushankova N.A., Shtansky D.V. INVESTIGATION OF BORON INFLUENCE ON THE STRUCTURE AND PROPERTIES OF MULTICOMPONENT NANOSTRUCTURED TiCaPCON COATINGS. Powder Metallurgy аnd Functional Coatings (Izvestiya Vuzov. Poroshkovaya Metallurgiya i Funktsional'nye Pokrytiya). 2016;(4):94-103. (In Russ.) https://doi.org/10.17073/1997-308X-2016-4-94-103
Views:
908
Email this article 